2008 TOYOTA Highlander Recalls, Complaints and Investigations

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

13 Recalls for 2008 TOYOTA Highlander

Recall Date	Component	Summary
2016-06-02	SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER	Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed. Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
2015-10-22	VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts. Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota’s number for this recall is C0M.
2014-11-19	SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER	Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4×2 and 4×4, Camry, Highlander, Tundra 4×2 and 4×4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring. Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
2014-04-09	AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE	Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver’s airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC’s retainer, the FFC could become damaged when the steering wheel is turned. Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
2012-10-10	VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat. Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
2011-04-21	AIR BAGS \| AIR BAGS:SIDE/WINDOW	TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED. Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
2010-01-27	VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER’S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388). Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
2010-02-03	EQUIPMENT:OTHER:LABELS	SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, “TIRE SELECTION AND RIMS.” THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS. Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
2010-02-03	EQUIPMENT:OTHER:LABELS	GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, “TIRE SELECTION AND RIMS.” THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS. Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER’S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
2009-06-15	EQUIPMENT:OTHER:LABELS	TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, “TIRE SELECTION AND RIMS.” Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
2009-05-14	EQUIPMENT	SOUTHEAST TOYOTA IS RECALLING 3,499 STAINLESS STEEL EXHAUST TIPS SOLD BY SOUTHEAST TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBIRD VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK. Remedy: SOUTHEAST TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY/JUNE 2009. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER LOYALTY DEPARTMENT AT 1-800-301-6859.
2009-04-27	EQUIPMENT	TOYOTA IS RECALLING 39,100 STAINLESS STEEL EXHAUST TIPS SOLD BY TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBRID VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE TOYOTA STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK. Remedy: TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2009. OWNERS MAY CONTACT TOYOTA CUSTOMER EXPERIENCE CENTER AT 1 888-270-9371 MONDAY THROUGH FRIDAY, 5:00 AM TO 6:00 PM, SATURDAY 7:00 AM THROUGH 4:00 PM PACIFIC TIME.
2008-04-18	SEAT BELTS:REAR/OTHER	TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, “OCCUPANT CRASH PROTECTION.” THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP) ON THESE VEHICLES IS EQUIPPED WITH SEAT BELT ASSEMBLIES THAT HAVE A FEATURE THAT CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) TO AN AUTOMATIC LOCKING RETRACTOR (ALR). THE BELTS CONVERT TO THE ALR MODE AFTER THE WEBBING HAS BEEN FULLY WITHDRAWN FROM THE RETRACTOR. THE SYSTEM IS DESIGNED SO THAT AS THE BELT IS RELEASED INTO THE RETRACTOR, THE SYSTEM REMAINS IN THE ALR MODE SO THAT A CHILD RESTRAINT SYSTEM (CRS) CAN BE TIGHTLY SECURED. Remedy: DEALERS WILL INSTALL A NEWLY DESIGNED SEAT BELT COMPONENT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 18, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

4 Complaints sent to the Center for Auto Safety for 2008 TOYOTA Highlander

skip to NHTSA complaints

Date			Component
2017-09-08
2012-01-11			engine
2011-05-12			mirrors
2011-05-12			airbag

355 Complaints submitted to NHTSA for 2008 TOYOTA Highlander

skip to CAS complaints

Date			Component
2010-06-03			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10334855
2017-04-18			FUEL/PROPULSION SYSTEM ODI Number: 10979143
2021-05-06			SERVICE BRAKES ODI Number: 11415447
2021-04-20			SERVICE BRAKES ODI Number: 11413044
2021-04-15			SERVICE BRAKES ODI Number: 11408283
2021-04-15			SERVICE BRAKES ODI Number: 11408267
2021-04-12			SERVICE BRAKES ODI Number: 11407738
2021-03-15			SERVICE BRAKES ODI Number: 11403006
2021-03-01			SERVICE BRAKES ODI Number: 11398479
2016-10-15			VEHICLE SPEED CONTROL ODI Number: 10916295
2016-09-26			ELECTRICAL SYSTEM ODI Number: 10909852
2016-10-01			STEERING ODI Number: 10910924
2017-07-18			AIR BAGS \| ELECTRONIC STABILITY CONTROL \| STEERING ODI Number: 11006121
2017-06-22			SERVICE BRAKES ODI Number: 11000661
2017-06-27			ENGINE ODI Number: 11001630
2017-06-17			STEERING ODI Number: 10995722
2017-06-04			ENGINE ODI Number: 10993075
2017-05-19			AIR BAGS ODI Number: 10990552
2017-05-16			ELECTRICAL SYSTEM \| SEATS ODI Number: 10986101
2017-05-03			VISIBILITY/WIPER ODI Number: 10983396
2017-05-01			STEERING ODI Number: 10981734
2017-08-15			ENGINE ODI Number: 11015413
2017-07-21			ENGINE ODI Number: 11006730
2016-08-19			SERVICE BRAKES ODI Number: 10897229
2017-03-03			SERVICE BRAKES ODI Number: 10958538
2017-03-18			ENGINE ODI Number: 10966643
2017-01-17			AIR BAGS ODI Number: 10945709
2020-12-09			SERVICE BRAKES \| STEERING ODI Number: 11382796
2020-12-14			ENGINE ODI Number: 11383381
2020-11-19			ENGINE ODI Number: 11375362
2020-12-03			ENGINE ODI Number: 11377733
2016-12-23			STEERING ODI Number: 10937248
2016-12-05			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES ODI Number: 10929981
2020-11-12			SERVICE BRAKES \| SUSPENSION \| VEHICLE SPEED CONTROL ODI Number: 11374370
2020-09-13			STEERING ODI Number: 11354803
2020-09-15			ELECTRICAL SYSTEM \| ENGINE \| FUEL/PROPULSION SYSTEM ODI Number: 11355261
2020-09-09			ENGINE ODI Number: 11354006
2020-08-24			STEERING ODI Number: 11350851
2020-07-20			ENGINE ODI Number: 11340439
2020-07-12			ELECTRICAL SYSTEM \| ENGINE \| FUEL/PROPULSION SYSTEM ODI Number: 11338931
2020-07-07			ELECTRICAL SYSTEM \| ELECTRONIC STABILITY CONTROL \| UNKNOWN OR OTHER ODI Number: 11337872
2020-07-03			SERVICE BRAKES ODI Number: 11337284
2020-06-15			ENGINE \| UNKNOWN OR OTHER ODI Number: 11328848
2020-05-22			ENGINE ODI Number: 11325617
2020-05-08			SERVICE BRAKES ODI Number: 11323883
2020-03-24			ENGINE ODI Number: 11319173
2020-02-28			SERVICE BRAKES ODI Number: 11312153
2020-02-27			ENGINE ODI Number: 11311913
2020-02-09			SERVICE BRAKES ODI Number: 11308098
2020-02-13			VEHICLE SPEED CONTROL ODI Number: 11308932
2020-02-13			VEHICLE SPEED CONTROL ODI Number: 11308931
2020-02-11			VISIBILITY:SUN/MOON ROOF ASSEMBLY ODI Number: 11308585
2020-02-06			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES ODI Number: 11307403
2020-01-03			AIR BAGS ODI Number: 11296962
2019-12-28			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES \| STEERING ODI Number: 11291811
2019-12-12			VISIBILITY/WIPER ODI Number: 11288651
2019-12-07			ENGINE ODI Number: 11287671
2019-11-25			ELECTRICAL SYSTEM \| ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES ODI Number: 11282336
2019-11-13			SERVICE BRAKES ODI Number: 11279726
2019-10-22			SERVICE BRAKES ODI Number: 11270147
2019-10-29			STEERING ODI Number: 11276877
2019-08-15			ENGINE ODI Number: 11244249
2019-08-10			STEERING ODI Number: 11243002
2019-08-14			SERVICE BRAKES ODI Number: 11244055
2019-07-15			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES ODI Number: 11231847
2019-07-24			ENGINE ODI Number: 11234326
2019-09-30			SERVICE BRAKES ODI Number: 11258917
2019-10-07			STEERING ODI Number: 11266832
2019-09-25			ENGINE ODI Number: 11258179
2019-09-13			ELECTRICAL SYSTEM \| ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES ODI Number: 11255430
2019-09-18			WHEELS ODI Number: 11256545
2019-05-21			ENGINE ODI Number: 11209101
2019-04-03			STEERING ODI Number: 11193581
2019-05-31			ENGINE ODI Number: 11217171
2019-01-11			STEERING ODI Number: 11166551
2019-01-22			UNKNOWN OR OTHER ODI Number: 11171329
2018-12-23			STEERING ODI Number: 11163196
2018-12-18			SERVICE BRAKES ODI Number: 11162223
2018-12-08			STEERING ODI Number: 11156953
2018-09-24			STEERING ODI Number: 11131103
2018-09-20			SERVICE BRAKES ODI Number: 11130309
2018-08-20			SERVICE BRAKES ODI Number: 11121056
2018-05-17			STEERING ODI Number: 11096640
2018-05-23			AIR BAGS \| STEERING ODI Number: 11097552
2019-03-21			STEERING ODI Number: 11190625
2019-03-19			STEERING ODI Number: 11189911
2019-02-25			SERVICE BRAKES ODI Number: 11182327
2019-03-12			AIR BAGS \| AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE \| ELECTRICAL SYSTEM ODI Number: 11183010
2018-04-10			SERVICE BRAKES ODI Number: 11084339
2018-02-28			ELECTRICAL SYSTEM \| VISIBILITY/WIPER ODI Number: 11075416
2018-02-13			FUEL/PROPULSION SYSTEM ODI Number: 11072446
2018-12-04			UNKNOWN OR OTHER ODI Number: 11155887
2018-10-22			STEERING ODI Number: 11141761
2018-08-06			AIR BAGS ODI Number: 11118035
2018-06-28			ENGINE ODI Number: 11104470
2018-02-02			POWER TRAIN ODI Number: 11066624
2018-01-23			UNKNOWN OR OTHER ODI Number: 11064527
2017-09-18			ENGINE ODI Number: 11023908
2016-07-26			TIRES:TREAD/BELT ODI Number: 10888757
2016-07-24			SERVICE BRAKES \| STEERING ODI Number: 10888043
2016-07-04			VISIBILITY/WIPER ODI Number: 10882489
2016-06-27			AIR BAGS ODI Number: 10876843
2016-04-29			VEHICLE SPEED CONTROL ODI Number: 10862117
2016-03-11			UNKNOWN OR OTHER ODI Number: 10846083
2016-02-14			AIR BAGS ODI Number: 10826042
2016-02-10			VEHICLE SPEED CONTROL ODI Number: 10825503
2016-01-10			STEERING ODI Number: 10819234
2015-12-28			STEERING ODI Number: 10816445
2015-12-30			ENGINE ODI Number: 10817136
2015-12-28			ENGINE ODI Number: 10816474
2015-12-21			AIR BAGS ODI Number: 10811463
2015-10-27			WHEELS ODI Number: 10786529
2015-10-28			ENGINE ODI Number: 10786744
2015-10-21			STEERING \| SUSPENSION \| UNKNOWN OR OTHER ODI Number: 10784946
2015-10-13			ENGINE ODI Number: 10781801
2015-10-14			ENGINE ODI Number: 10781914
2015-10-01			UNKNOWN OR OTHER ODI Number: 10779108
2015-09-22			AIR BAGS \| STRUCTURE:BODY \| WHEELS ODI Number: 10767464
2015-09-04			ELECTRICAL SYSTEM ODI Number: 10761460
2015-09-02			AIR BAGS ODI Number: 10761124
2015-08-24			AIR BAGS ODI Number: 10758918
2015-07-21			AIR BAGS ODI Number: 10735566
2015-07-27			AIR BAGS \| VEHICLE SPEED CONTROL ODI Number: 10743918
2015-07-10			SERVICE BRAKES ODI Number: 10733345
2015-07-14			ELECTRICAL SYSTEM ODI Number: 10733843
2015-06-27			UNKNOWN OR OTHER ODI Number: 10730807
2015-06-22			ENGINE ODI Number: 10726484
2015-06-06			ENGINE \| UNKNOWN OR OTHER ODI Number: 10723756
2015-05-15			ENGINE \| FUEL/PROPULSION SYSTEM ODI Number: 10716697
2015-05-03			STRUCTURE:BODY \| VISIBILITY ODI Number: 10714240
2015-05-01			AIR BAGS ODI Number: 10714125
2015-04-08			ENGINE ODI Number: 10704454
2015-03-26			ELECTRICAL SYSTEM ODI Number: 10702015
2015-04-02			STRUCTURE:BODY ODI Number: 10703435
2015-03-08			EXTERIOR LIGHTING ODI Number: 10692826
2015-03-10			STEERING ODI Number: 10693222
2015-02-17			STEERING ODI Number: 10683885
2015-02-13			STEERING ODI Number: 10683139
2015-02-02			STEERING ODI Number: 10680705
2014-12-29			STEERING ODI Number: 10668821
2014-12-15			VEHICLE SPEED CONTROL ODI Number: 10664471
2014-12-12			VEHICLE SPEED CONTROL ODI Number: 10663950
2014-11-20			AIR BAGS ODI Number: 10659730
2014-12-16			UNKNOWN OR OTHER ODI Number: 10659546
2014-11-15			ENGINE ODI Number: 10655236
2014-10-25			ENGINE AND ENGINE COOLING ODI Number: 10649917
2014-10-24			AIR BAGS ODI Number: 10649835
2014-10-13			ENGINE AND ENGINE COOLING ODI Number: 10644369
2014-09-23			SEAT BELTS ODI Number: 10638304
2014-09-26			AIR BAGS \| ELECTRICAL SYSTEM \| VEHICLE SPEED CONTROL ODI Number: 10639429
2014-09-18			ENGINE ODI Number: 10637334
2014-09-30			AIR BAGS ODI Number: 10638956
2014-08-26			STRUCTURE:BODY \| SUSPENSION \| UNKNOWN OR OTHER ODI Number: 10628611
2014-08-07			AIR BAGS ODI Number: 10619565
2014-07-22			WHEELS ODI Number: 10615334
2014-07-10			ENGINE AND ENGINE COOLING ODI Number: 10609514
2014-07-03			ELECTRICAL SYSTEM ODI Number: 10608005
2014-06-28			ENGINE AND ENGINE COOLING \| POWER TRAIN ODI Number: 10606639
2014-06-17			ELECTRICAL SYSTEM \| ENGINE \| STEERING ODI Number: 10598817
2014-06-17			AIR BAGS \| STRUCTURE:BODY ODI Number: 10598789
2014-05-28			ENGINE ODI Number: 10594692
2014-05-21			ENGINE ODI Number: 10593150
2014-05-20			ELECTRICAL SYSTEM ODI Number: 10592653
2014-05-27			AIR BAGS ODI Number: 10594184
2014-05-12			ENGINE ODI Number: 10587715
2014-04-10			SEAT BELTS ODI Number: 10578836
2014-04-14			POWER TRAIN ODI Number: 10582784
2014-04-02			AIR BAGS \| SERVICE BRAKES ODI Number: 10576766
2014-04-01			AIR BAGS ODI Number: 10576305
2014-03-20			ENGINE ODI Number: 10573890
2014-03-24			ENGINE ODI Number: 10574587
2014-04-01			AIR BAGS ODI Number: 10576130
2014-03-19			AIR BAGS ODI Number: 10573574
2014-03-19			AIR BAGS ODI Number: 10573365
2014-02-27			AIR BAGS ODI Number: 10566383
2014-02-18			EQUIPMENT \| LATCHES/LOCKS/LINKAGES ODI Number: 10564832
2014-02-24			ENGINE ODI Number: 10565662
2014-01-31			ELECTRICAL SYSTEM \| VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM ODI Number: 10562394
2014-02-04			AIR BAGS ODI Number: 10562850
2014-02-07			SERVICE BRAKES ODI Number: 10563450
2014-02-03			ELECTRICAL SYSTEM ODI Number: 10562635
2014-01-09			ENGINE ODI Number: 10559272
2013-12-27			SERVICE BRAKES ODI Number: 10557373
2013-12-07			AIR BAGS ODI Number: 10555167
2013-12-12			ELECTRICAL SYSTEM ODI Number: 10555805
2013-11-12			ENGINE ODI Number: 10551969
2013-10-20			STRUCTURE:BODY ODI Number: 10548644
2013-10-25			AIR BAGS ODI Number: 10549590
2013-10-07			ENGINE ODI Number: 10547073
2013-09-30			AIR BAGS ODI Number: 10546162
2013-10-03			ENGINE AND ENGINE COOLING ODI Number: 10546616
2013-09-19			ENGINE ODI Number: 10544453
2013-09-18			ENGINE ODI Number: 10544257
2013-09-24			AIR BAGS ODI Number: 10545121
2013-09-09			ELECTRICAL SYSTEM \| EQUIPMENT ADAPTIVE/MOBILITY ODI Number: 10542788
2013-09-03			AIR BAGS \| ELECTRICAL SYSTEM ODI Number: 10541688
2013-08-26			ELECTRICAL SYSTEM ODI Number: 10537324
2013-07-25			ENGINE ODI Number: 10531854
2013-07-20			HYBRID PROPULSION SYSTEM: INVERTER \| POWER TRAIN ODI Number: 10525905
2013-07-29			AIR BAGS ODI Number: 10532337
2013-07-07			VISIBILITY/WIPER ODI Number: 10523585
2013-07-05			AIR BAGS ODI Number: 10523330
2013-06-27			ENGINE ODI Number: 10522031
2013-06-27			ENGINE ODI Number: 10522145
2013-06-13			AIR BAGS ODI Number: 10519645
2013-06-17			AIR BAGS ODI Number: 10520207
2013-06-14			AIR BAGS ODI Number: 10519852
2013-06-07			AIR BAGS ODI Number: 10515688
2013-05-17			AIR BAGS ODI Number: 10512562
2013-05-20			AIR BAGS ODI Number: 10512869
2013-05-01			ENGINE AND ENGINE COOLING ODI Number: 10510227
2013-04-08			ENGINE ODI Number: 10507486
2013-03-16			STEERING ODI Number: 10503276
2013-03-27			VISIBILITY ODI Number: 10504773
2013-03-24			ENGINE ODI Number: 10504314
2013-03-12			SEAT BELTS:REAR/OTHER ODI Number: 10502901
2013-02-07			SEATS ODI Number: 10496789
2013-02-07			ENGINE ODI Number: 10496756
2013-02-13			SERVICE BRAKES ODI Number: 10497997
2013-02-08			HYBRID PROPULSION SYSTEM: INVERTER ODI Number: 10496829
2013-01-28			VISIBILITY/WIPER ODI Number: 10494941
2012-12-15			ELECTRICAL SYSTEM \| STEERING ODI Number: 10488862
2012-11-20			SEAT BELTS \| STEERING ODI Number: 10485260
2012-11-15			AIR BAGS \| ELECTRICAL SYSTEM ODI Number: 10484825
2012-10-01			ELECTRICAL SYSTEM ODI Number: 10478205
2012-09-21			AIR BAGS \| ELECTRICAL SYSTEM ODI Number: 10476707
2012-09-19			VEHICLE SPEED CONTROL ODI Number: 10475966
2012-09-18			STEERING ODI Number: 10475876
2012-08-15			EXTERIOR LIGHTING ODI Number: 10470750
2012-08-14			AIR BAGS \| SERVICE BRAKES ODI Number: 10470586
2012-08-23			EQUIPMENT:APPLIANCE:AIR CONDITIONER ODI Number: 10472057
2012-07-05			ELECTRONIC STABILITY CONTROL \| ENGINE AND ENGINE COOLING ODI Number: 10464369
2012-06-21			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES ODI Number: 10462589
2012-03-16			VISIBILITY ODI Number: 10451991
2012-02-28			ELECTRONIC STABILITY CONTROL \| ENGINE AND ENGINE COOLING ODI Number: 10449547
2012-01-28			SERVICE BRAKES, HYDRAULIC ODI Number: 10445693
2012-02-02			ENGINE AND ENGINE COOLING ODI Number: 10446270
2012-01-18			AIR BAGS ODI Number: 10444409
2011-12-14			VEHICLE SPEED CONTROL ODI Number: 10439862
2011-11-23			ENGINE AND ENGINE COOLING ODI Number: 10436825
2011-10-06			ELECTRICAL SYSTEM \| ELECTRONIC STABILITY CONTROL ODI Number: 10428905
2011-10-05			AIR BAGS ODI Number: 10428765
2011-09-26			STRUCTURE:BODY ODI Number: 10427216
2011-07-15			AIR BAGS ODI Number: 10412401
2011-06-01			EQUIPMENT:MECHANICAL:ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT ODI Number: 10404005
2011-05-25			WHEELS ODI Number: 10402677
2011-05-17			STEERING ODI Number: 10401333
2011-05-08			CHILD SEAT ODI Number: 10399478
2011-05-12			AIR BAGS ODI Number: 10400619
2011-05-14			ELECTRONIC STABILITY CONTROL \| SUSPENSION ODI Number: 10400860
2011-04-18			LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH ODI Number: 10396717
2011-04-11			SERVICE BRAKES, HYDRAULIC ODI Number: 10395540
2011-03-07			AIR BAGS ODI Number: 10386697
2011-02-18			ENGINE AND ENGINE COOLING:COOLING SYSTEM \| SUSPENSION ODI Number: 10383688
2011-02-20			STRUCTURE \| TIRES:TEMPORARY/EMERGENCY SPARE TIRE ODI Number: 10383392
2011-02-02			VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM ODI Number: 10379953
2011-01-29			FUEL SYSTEM, GASOLINE \| SERVICE BRAKES, HYDRAULIC \| VEHICLE SPEED CONTROL ODI Number: 10380388
2010-12-30			TIRES ODI Number: 10373475
2010-12-30			ELECTRICAL SYSTEM \| ELECTRONIC STABILITY CONTROL ODI Number: 10373470
2010-11-18			ENGINE AND ENGINE COOLING:ENGINE \| POWER TRAIN:AUTOMATIC TRANSMISSION \| POWER TRAIN:AXLE ASSEMBLY ODI Number: 10366664
2010-10-31			FUEL SYSTEM, GASOLINE ODI Number: 10363417
2010-10-12			TIRES ODI Number: 10360109
2010-10-19			TIRES ODI Number: 10361283
2010-09-19			TIRES ODI Number: 10356370
2010-08-23			ELECTRICAL SYSTEM ODI Number: 10351257
2010-08-21			SERVICE BRAKES, ELECTRIC ODI Number: 10351064
2010-08-20			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10350710
2010-07-27			SEAT BELTS ODI Number: 10345693
2010-07-29			TIRES ODI Number: 10346119
2010-07-27			AIR BAGS:SIDE/WINDOW ODI Number: 10345743
2010-07-19			VEHICLE SPEED CONTROL ODI Number: 10343947
2010-07-06			ENGINE AND ENGINE COOLING ODI Number: 10341684
2010-07-12			TIRES ODI Number: 10342801
2010-07-01			TIRES ODI Number: 10340976
2010-06-28			VEHICLE SPEED CONTROL ODI Number: 10340405
2010-06-06			TIRES ODI Number: 10334812
2010-06-06			TIRES ODI Number: 10334786
2010-06-01			UNKNOWN OR OTHER \| VEHICLE SPEED CONTROL ODI Number: 10334122
2010-06-03			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10334855
2010-05-18			VEHICLE SPEED CONTROL ODI Number: 10331025
2010-05-03			POWER TRAIN:AUTOMATIC TRANSMISSION \| TIRES ODI Number: 10328714
2010-04-08			TIRES ODI Number: 10324566
2010-04-20			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10326622
2010-04-10			EQUIPMENT ADAPTIVE/MOBILITY \| VEHICLE SPEED CONTROL ODI Number: 10324837
2010-04-13			TIRES ODI Number: 10325496
2010-04-07			VEHICLE SPEED CONTROL ODI Number: 10324367
2010-03-25			ELECTRICAL SYSTEM \| VEHICLE SPEED CONTROL ODI Number: 10322088
2010-04-05			POWER TRAIN:AXLE ASSEMBLY ODI Number: 10323791
2010-03-23			TIRES ODI Number: 10321686
2010-04-06			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10324051
2010-04-05			POWER TRAIN \| VEHICLE SPEED CONTROL ODI Number: 10323859
2010-03-12			VEHICLE SPEED CONTROL ODI Number: 10319270
2010-03-11			AIR BAGS:FRONTAL ODI Number: 10319072
2010-03-17			VEHICLE SPEED CONTROL ODI Number: 10320466
2010-03-16			SERVICE BRAKES, HYDRAULIC \| VEHICLE SPEED CONTROL ODI Number: 10320164
2010-03-18			SEAT BELTS \| VISIBILITY:WINDSHIELD ODI Number: 10320768
2010-03-08			TIRES ODI Number: 10317676
2010-03-06			POWER TRAIN:DRIVELINE \| POWER TRAIN:MANUAL TRANSMISSION ODI Number: 10317304
2010-03-04			VEHICLE SPEED CONTROL ODI Number: 10316864
2010-03-10			EQUIPMENT ADAPTIVE/MOBILITY \| VEHICLE SPEED CONTROL ODI Number: 10318488
2010-03-08			SERVICE BRAKES, HYDRAULIC ODI Number: 10317885
2010-03-03			VEHICLE SPEED CONTROL ODI Number: 10316344
2010-03-01			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10315228
2010-02-25			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10314136
2010-02-21			VEHICLE SPEED CONTROL ODI Number: 10312489
2010-02-20			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES, HYDRAULIC ODI Number: 10312322
2010-02-24			ENGINE AND ENGINE COOLING ODI Number: 10313918
2010-02-19			STEERING ODI Number: 10312135
2010-02-23			VEHICLE SPEED CONTROL ODI Number: 10313334
2010-02-23			STEERING \| VEHICLE SPEED CONTROL ODI Number: 10313330
2010-02-12			SERVICE BRAKES, HYDRAULIC ODI Number: 10308853
2010-02-15			ELECTRICAL SYSTEM ODI Number: 10310539
2010-02-10			POWER TRAIN \| VEHICLE SPEED CONTROL ODI Number: 10308314
2010-02-10			FUEL SYSTEM, GASOLINE \| POWER TRAIN ODI Number: 10308598
2010-02-09			VEHICLE SPEED CONTROL ODI Number: 10307812
2010-02-08			ELECTRICAL SYSTEM ODI Number: 10307495
2010-02-07			TIRES ODI Number: 10307335
2010-02-06			TIRES ODI Number: 10306997
2010-02-09			SUSPENSION ODI Number: 10307919
2010-02-08			ELECTRICAL SYSTEM \| FUEL SYSTEM, GASOLINE ODI Number: 10307434
2010-02-09			SERVICE BRAKES, HYDRAULIC ODI Number: 10308219
2010-02-05			POWER TRAIN:AUTOMATIC TRANSMISSION \| VEHICLE SPEED CONTROL ODI Number: 10306609
2010-02-05			SERVICE BRAKES, HYDRAULIC ODI Number: 10306576
2010-02-10			SERVICE BRAKES, ELECTRIC ODI Number: 10308305
2010-02-09			VEHICLE SPEED CONTROL ODI Number: 10307834
2010-02-02			VEHICLE SPEED CONTROL ODI Number: 10304032
2010-02-03			VEHICLE SPEED CONTROL ODI Number: 10304297
2010-02-02			POWER TRAIN ODI Number: 10303774
2009-12-10			SEATS ODI Number: 10295218
2009-11-30			VEHICLE SPEED CONTROL ODI Number: 10294068
2009-11-04			TIRES ODI Number: 10291016
2009-10-10			TIRES ODI Number: 10286964
2009-09-23			TIRES ODI Number: 10285064
2009-10-08			VEHICLE SPEED CONTROL ODI Number: 10286777
2009-09-11			SERVICE BRAKES, HYDRAULIC \| SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM ODI Number: 10283659
2009-09-02			TIRES ODI Number: 10282674
2009-08-26			SERVICE BRAKES, HYDRAULIC ODI Number: 10281831
2009-07-09			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10276252
2009-05-04			TIRES ODI Number: 10267657
2009-05-04			EXTERIOR LIGHTING \| VISIBILITY ODI Number: 10267713
2009-04-19			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10266001
2009-04-10			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10264947
2009-03-05			TIRES ODI Number: 10260844
2009-03-13			VEHICLE SPEED CONTROL ODI Number: 10261772
2008-12-22			ELECTRICAL SYSTEM ODI Number: 10252531
2008-07-30			VEHICLE SPEED CONTROL ODI Number: 10236346
2008-04-15			POWER TRAIN ODI Number: 10224632
2008-04-24			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10226195
2008-04-04			FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY ODI Number: 10223935
2008-03-14			VISIBILITY:SUN/MOON ROOF ASSEMBLY ODI Number: 10221208
2008-02-17			VISIBILITY:WINDSHIELD ODI Number: 10218253
2007-11-27			ELECTRICAL SYSTEM:SOFTWARE \| STRUCTURE ODI Number: 10210048
2020-07-07			ENGINE ODI Number: 11338000
2009-01-25			TIRES ODI Number: 10256300
2010-02-07			SERVICE BRAKES, HYDRAULIC ODI Number: 10307300

Is the government investigating the safety of your vehicle? Find out here.

4 Investigations for 2008 TOYOTA Highlander

On may 4, 2018, the office of defects investigation (odi) opened preliminary evaluation pe18-005 to investigate three allegations of steering column separation for model year (my) 2008 through 2013 toyota highlander vehicles. two (2) of the 3 complaints were received by odi in april 2018 and occurred while the vehicle was in motion. as part of pe18-005, odi analyzed additional incidents reported through the vehicle owner questionnaire (voq) process and examined the field data, warranty data, and relevant technical information submitted by toyota in response to the pe18-005 information request letter. during pe18-005, odi confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. this design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. there is no direct method for detecting when the capsules in the subject vehicles have sheared. if the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash. to date, odi has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. one of these incidents involved a minor crash. additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. four of these incidents happened while driving. of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.this investigation has been upgraded to an engineering analysis in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repairbreakaway capsules after they have separated. toyota has recently revised their repair manual and issued a collision repair information bulletin to help address the second concern.the voqs associated with the opening of this investigation can be viewed at www.nhtsa.gov under the following odi complaint numbers: 11141761, 11083623, 11083280, 10888043.

On may 4, 2018, the office of defects investigation (odi) opened preliminary evaluation pe18-005 to investigate three allegations of steering column separation for model year (my) 2008 through 2013 toyota highlander vehicles. two (2) of the 3 complaints were received by odi in april 2018 and occurred while the vehicle was in motion. since opening pe18-005, one (1) additional voq involving steering column separation has been received. this incident occurred while the vehicle was stationary.as part of pe18-005, odi examined the field data, warranty data, and relevant technical information submitted by toyota in response to the pe18-005 information request letter. ten (10) additional incidents of steering column separation were identified. four (4) of these instances occurred while driving. during pe18-005, odi confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. this design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. there is no direct method for detecting when the capsules in the subject vehicles have sheared. if the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.to date, odi has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. one of these incidents involved a minor crash. additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. four of these incidents happened while driving. of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.this investigation has been upgraded an to engineering analysis (ea18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. toyota has recently revised their repair manual and issued a collision repair information bulletin to help address the second concern.the voqs associated with this investigation can be viewed at www.nhtsa.gov under the following odi complaint numbers: 11141761, 11083623, 11083280, 10888043.

Date Opened	Date Closed	Component
2018-11-16		STEERING:COLUMN
2018-11-16		STEERING
2018-05-04	2018-11-20	STEERING:COLUMN
2018-05-04	2018-11-20	STEERING

Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

320 Service Alerts for 2008 TOYOTA Highlander

Date	Description
2024-12-06	STRUCTURE:BODY The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicl Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2024-12-06	STRUCTURE:BODY To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and in Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2024-12-06	STRUCTURE:BODY Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2024-12-05	STRUCTURE:BODY Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination. Follow the Removal Procedure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2024-12-03	STRUCTURE:BODY Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. This type of contamination can be identified by the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-14	350000 EQUIPMENT Toyota Safety Recall and Service Campaign – Technician Certification Requirements 4.14.2022 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-17	030000 SERVICE BRAKES, HYDRAULIC TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-17	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-28	350000 EQUIPMENT CSP: Customer Support Program ZKG – Paint Repair Process Operation Flow Chart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-28	160000 STRUCTURE DD: Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Toyota has added approximately 430,700 2008 ? 2018 model year Highlander and H Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-28	350000 EQUIPMENT DD: Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Toyota has added approximately 430,700 2008 ? 2018 model year Highlander and H Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-28	160000 STRUCTURE DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-28	350000 EQUIPMENT DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-28	160000 STRUCTURE TI: Technical Instructions Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-28	350000 EQUIPMENT TI: Technical Instructions Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-09	050000 PARKING BRAKE TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the Repair Procedure in this bulletin to replace the loose or damaged carpet floor retai Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	190000 TIRES POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	200000 WHEELS POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-06	980000 UNKNOWN OR OTHER TI: LSC 90K Expired on December 31, 2021 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-11-23	160000 STRUCTURE TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2001-05-04	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Replacement vin plates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1991-01-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1989-06-30	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1993-04-09	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1991-01-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-17	140000 AIR BAGS Toyota Safety Recall and Service Campaign – Technician Certification Requirements Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-12	030000 BRAKES (PWS) TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-12	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0044-16. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-08-23	162620 STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT TOYOTA: THE REAR LIFT GLASS HATCH EXHIBITS A POSSIBLE CONDITION WHEREBY IT FAILS CLOSE PROPERLY. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-02-03	350000 EQUIPMENT TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	030000 BRAKES (PWS) TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-21	062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS TT: HVAC drain tube is found to be blocked/clogged. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	030000 SERVICE BRAKES, HYDRAULIC TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-14	353000 EQUIPMENT:ELECTRICAL TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Perform t Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-03	063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but part Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-05	062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-05	110000 ELECTRICAL SYSTEM TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-05	350000 EQUIPMENT TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-11	110000 ELECTRICAL SYSTEM TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-11	060000 ENGINE (PWS) TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-11	110000 ELECTRICAL SYSTEM TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-11	060000 ENGINE (PWS) TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-23	020000 SUSPENSION TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see T-SB-0063-20. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-23	200000 WHEELS TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-11	110000 ELECTRICAL SYSTEM TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-11	060000 ENGINE (PWS) TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-11	110000 ELECTRICAL SYSTEM TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-11	060000 ENGINE (PWS) TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-18	110000 ELECTRICAL SYSTEM TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Perform t Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-30	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM TT: HVAC drain tube is found to be blocked/clogged. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-03	063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but part Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-07	350000 EQUIPMENT TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-06	350000 EQUIPMENT TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-01	110000 ELECTRICAL SYSTEM TT: This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue ch Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-02-06	350000 EQUIPMENT TSB: Some 2004 ? 2017 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-02-12	350000 EQUIPMENT OBSOLETE NOTICE February 12, 2020: This bulletin is now obsolete. Please see T-SB-0010-20. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-01-27	350000 EQUIPMENT TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-09	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: OBSOLETE NOTICE July 9, 2019: This bulletin is now obsolete. Please see T-SB-0080-19. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-09	356000 EQUIPMENT ADAPTIVE/MOBILITY TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	100000 POWER TRAIN TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	110000 ELECTRICAL SYSTEM TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	060000 ENGINE (PWS) TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-05-24	036400 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT TSB: Some 2008 ? 2010 model year Highlander Hybrid vehicles may exhibit a condition where the brake, ABS, and/or TRAC warning light(s) are on and/or a Check VSC message displays. Diagnostic Trouble Codes (DTCs) C1391, C1252, C1253, and C125 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-14	060000 ENGINE (PWS) TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Sma Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Sma Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Sma Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-25	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TT: HVAC drain tube is found to be blocked/clogged. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-14	110000 ELECTRICAL SYSTEM TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Sma Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-12-02	350000 EQUIPMENT TSB: This bulletin includes basic procedures for performing a Rescue Charge on Ni-MH High Voltage (HV) Batteries. This bulletin should be used in conjunction with the Repair Manual while performing Rescue Charge. The GRX-5100 should be used Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-01-06	110000 ELECTRICAL SYSTEM TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-21	350000 EQUIPMENT Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-21	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-07-31	350000 EQUIPMENT TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	350000 EQUIPMENT Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	355100 EQUIPMENT:OTHER:LABELS Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	350000 EQUIPMENT Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	355100 EQUIPMENT:OTHER:LABELS Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-11	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY TT: HV Batteries have liquid filled cell modules, to prevent leakage from cells, it is very important to confirm the proper orientation mark of the DRC. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-11	350000 EQUIPMENT TT: HV Batteries have liquid filled cell modules, to prevent leakage from cells, it is very important to confirm the proper orientation mark of the DRC. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-04-26	011000 STEERING: STEERING WHEEL/HANDLE BAR TSB: REVISION NOTICE: April 26, 2017 Rev1: G361 ? The Parts Information section has been updated. Some 2008 ? 2013 model year Highlander and Highlander HV vehicles may exhibit a clunk, pop, or knock-type noise when turning the steering whee Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-04-26	014100 STEERING:RACK AND PINION:PINION SHAFT TSB: REVISION NOTICE: April 26, 2017 Rev1: G361 ? The Parts Information section has been updated. Some 2008 ? 2013 model year Highlander and Highlander HV vehicles may exhibit a clunk, pop, or knock-type noise when turning the steering whee Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-04-06	110000 ELECTRICAL SYSTEM Warranty Policy Bulletin POL17-04: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and then reverse to the open po Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-04-06	350000 EQUIPMENT Warranty Policy Bulletin POL17-04: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and then reverse to the open po Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-06-20	171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and then reverse to the open position. I Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	100000 POWER TRAIN As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-26	110000 ELECTRICAL SYSTEM The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. If the operator attempts to ready-on or start the vehicle while there is tension on Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-08-24	100000 POWER TRAIN TechTip: Condition – The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-03	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL In mid-April 2013 Toyota will be mailing an update to the Owner’s Manual for 2008 through 2012 Model Year Highlander and Highlander HV. Sample Owner labels are provided below for your reference. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	180000 VEHICLE SPEED CONTROL On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the third phase of a Limited Service Campaign to install Smar Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the third phase of a Limited Service Campaign to install Smar Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-18	110000 ELECTRICAL SYSTEM Some 2008-2012 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does not close properly. The Back Door may get to the fully closed position and then reverse to the open position. In cases Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-18	171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH Some 2008-2012 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does not close properly. The Back Door may get to the fully closed position and then reverse to the open position. In cases Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	110000 ELECTRICAL SYSTEM Some customers may complain that the Rear Seat Entertainment (RSE) system is inoperative if they have misplaced the parental passcode for the system. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	220000 SEATS Some customers may complain that the Rear Seat Entertainment (RSE) system is inoperative if they have misplaced the parental passcode for the system. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-15	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY Technicians should confirm the following key points to minimize the potential for future MIL “ON” concerns after HV battery replacement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	355100 EQUIPMENT:OTHER:LABELS This bulletin is now obsolete. Please see T-SB-0054-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	350000 EQUIPMENT California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-04	280000 BACK OVER PREVENTION If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-04	358100 EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-24	110000 ELECTRICAL SYSTEM TT: When replacing components on vehicles equipped with the Power Back Door option, please reference the following guide to ensure the correct parts are used in combination with each other. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-03-18	060000 ENGINE (PWS) TechTip: Condition: Engine No Start and/or Poor Engine Power DTCs set immediately after performing service on the Inverter such as SSC D0M for IPM replacement or Inverter Assembly Installation. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-01	162500 STRUCTURE:BODY:TAILGATE Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and then reverse to the open position. I Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-20	140000 AIR BAGS TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-20	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-01	100000 POWER TRAIN The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-19	130000 VISIBILITY/WIPER (PWS) This bulletin is now obsolete. Please see T-SB-0185-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-19	130000 VISIBILITY The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-23	132000 VISIBILITY:GLASS, SIDE/REAR The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	140000 AIR BAGS Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	220000 SEATS Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	350000 EQUIPMENT Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	110000 ELECTRICAL SYSTEM These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	353000 EQUIPMENT:ELECTRICAL These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER If a customer states there is an unpleasant odor in the vehicle from the HVAC system, there are various factors that may be involved. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-12	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	050000 PARKING BRAKE A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	350000 EQUIPMENT A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-11	118000 ELECTRICAL SYSTEM:SOFTWARE Tech Tip: Some customers may experience difficulty programming HomeLink. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	060000 ENGINE (PWS) TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-14	140000 AIR BAGS Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-11-21	350000 EQUIPMENT TSB: OBSOLETE NOTICE November 21, 2017: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-23	190000 TIRES Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-28	350000 EQUIPMENT Customer complains of Bluetooth connectivity concerns such as: Difficulty to pair phone, Intermittent Bluetooth failure to connect to the vehicle when first turning on the vehicle. These concerns can be caused by changes made on the custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-24	060000 ENGINE (PWS) Engine No Start and/or Poor Engine Power DTCs set immediately after performing service on the Inverter such as SSC D0M for IPM replacement or Inverter Assembly installation. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the third phase of a Limited Service Campaign to install Smar Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-21	011000 STEERING: STEERING WHEEL/HANDLE BAR Some 2008 ? 2013 model year Highlander and Highlander HV vehicles may exhibit a clunk, pop, or knock-type noise when turning the steering wheel left or right. A new intermediate shaft has been developed to address this condition. Use the fo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-25	011000 STEERING: STEERING WHEEL/HANDLE BAR The vehicle will not start or ready-on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-20	100000 POWER TRAIN This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-11-22	110000 ELECTRICAL SYSTEM TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-19	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Some customers may inquire about the frequency and power output of the Smart Key/Smart Entry systems used on various models. The Smart Key/Smart Entry systems conform to all applicable FCC rules. This bulletin details the applicable specifi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-08	140000 AIR BAGS Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-08	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: REVISION NOTICE March 08, 2017 Rev1: ? Applicability has been updated to include 2015 – 2017 model year Toyota vehicles. ? The Parts Information section has been updated. Some vehicles in particular geographic areas may exhibit a c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-08	140000 AIR BAGS Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-17	171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH TSB: OBSOLETE NOTICE March 17, 2017: This bulletin is now obsolete. Please see T-SB-0191-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-20	162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE Warranty Policy Bulletin POL17-04: REVISED March 01, 2017: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-01	162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE Warranty Policy Bulletin POL17-04: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully close position and then reverse to the open po Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-01	162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE Dealer Package: Certain 2008 – 2013 model year Highlander and Highlander Hybrid vehicles may exhibit a condition where the Power Back Door does not close properly. In some cases, the Power Back Door may reach the fully closed position and t Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-07	980000 UNKNOWN OR OTHER TSB: OBSOLETE NOTICE: July 7, 2014: This bulletin is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-07	353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-31	060000 ENGINE AND ENGINE COOLING Region Letter: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for repairs related a leaking or seeping Engine Oil Cooler Pipe. In th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Region Letter: Toyota will be sending Limited Service Campaign Notices to remind owners whose vehicles have not yet had Smart Stop Technology installed on their vehicle under LSC BST. Initial notification informing customers of the availabi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-25	353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-31	060000 ENGINE AND ENGINE COOLING Dealer Letter: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for repairs related a leaking or seeping Engine Oil Cooler Pipe. In th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Dealer Letter: Toyota will be sending Limited Service Campaign Notices to remind owners whose vehicles have not yet had Smart Stop Technology installed on their vehicle under LSC BST. Initial notification informing customers of the availabi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-26	110000 ELECTRICAL SYSTEM Warranty Policy Bulletin POL17-04: Rev Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and then reverse to the ope Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-12	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-07	062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN TSB: For vehicles that are used under certain severe operating conditions, the HV Battery Cooling Fan may experience an excessive buildup of dust, lint, or other debris that can reduce the efficiency of the HV Battery Cooling System. HV Ba Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-03-08	110000 ELECTRICAL SYSTEM TT: Some customers may encounter Bluetooth connectivity concerns such as: ? Difficulty pairing the phone. ? Intermittent Bluetooth failure to connect when first turning on the vehicle. ? Various Bluetooth Audio functions are no lon Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-27	110000 ELECTRICAL SYSTEM The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-07	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-09	100000 POWER TRAIN Some 2008 ? 2013 model year Highlander vehicles equipped with the 5-speed automatic transaxle may exhibit a whine noise from the final drive gear assembly. This noise is noticeable above 35 mph. Please refer to the repair procedure to addre Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-09	280000 BACK OVER PREVENTION Some 2008 ? 2013 model year Highlander vehicles equipped with the 5-speed automatic transaxle may exhibit a whine noise from the final drive gear assembly. This noise is noticeable above 35 mph. Please refer to the repair procedure to addre Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-08	280000 BACK OVER PREVENTION Some vehicles may exhibit a MIL ?ON? Diagnostic Trouble Code (DTC) P0138 and/or P0158 (Oxygen Sensor Circuit High Voltage Bank 1 or 2). In some instances a P2195 or P2197 (A/F Sensor Signal Stuck Lean) DTC may also be present. This conditio Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-01	060000 ENGINE (PWS) Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-01	280000 BACK OVER PREVENTION Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-03	110000 ELECTRICAL SYSTEM Some customers may complain that the Rear Seat Entertainment (RSE) system is inoperative if the have misplaced the parental passcode for the system. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-11-10	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Some 2004 ? 2017 model year Toyota vehicles may exhibit odor Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-11	180000 VEHICLE SPEED CONTROL On July 24, 2013 the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the second phase of a Limited Service Campaign to install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-11	180000 VEHICLE SPEED CONTROL On July 24, 2013 the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the second phase of a Limited Service Campaign to install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-10-23	171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and then reverse to the open position. I Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-11-29	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	060000 ENGINE (PWS) TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-22	162300 STRUCTURE:BODY:DOOR Some 2008-2012 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does no close properly. The Back Door may get to the fully closed position and then reverse to the open position. In cases w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-04	162000 STRUCTURE:BODY Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-22	190000 TIRES Please refer to the following recommendations for the best practices for vehicle tire rotations. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-02-12	190000 TIRES TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	110000 ELECTRICAL SYSTEM TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-03-18	100000 POWER TRAIN TechTip: Condition: Engine No Start and/or Poor Engine Power DTCs set immediately after performing service on the Inverter such as SSC D0M for IPM replacement or Inverter Assembly Installation. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-03-18	060000 ENGINE (PWS) TechTip: Condition: Engine No Start and/or Poor Engine Power DTCs set immediately after performing service on the Inverter such as SSC D0M for IPM replacement or Inverter Assembly Installation. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-02-28	171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH TSB: Some 2008 ? 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does not close properly. The Back Door may get to the fully closed position and then reverse to the open position. In Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-02-12	190000 TIRES TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-02-02	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 or P1AC000 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-01	162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE Dealer Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Power Back Door on certain 2008 – 2013 model year Highlander and Highlander Hybrid vehicles. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-01	162300 STRUCTURE:BODY:DOOR Region Letter: Certain 2008 – 2013 model year Highlander and Highlander Hybrid vehicles may exhibit a condition where the Power Back Door does not close properly. In some cases, the Power Back Door may reach the fully closed position and th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-01	162300 STRUCTURE:BODY:DOOR Region Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Power Back Door on certain 2008 – 2013 model year Highlander and Highlander Hybrid vehicles. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-01-11	350000 EQUIPMENT TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-11	350000 EQUIPMENT TECH TIP: SOME CUSTOMERS MAY EXPERIENCE DIFFICULTY PROGRAMMING HOMELINK. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	118000 ELECTRICAL SYSTEM:SOFTWARE Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-02	118000 ELECTRICAL SYSTEM:SOFTWARE Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-10	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY technicians should confirm the following key points to minimize the potential for future MIL “ON” concerns after HV Battery Replacement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-03	140000 AIR BAGS Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This bulletin is now obsolete. Please see T-SB-0012-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	030000 SERVICE BRAKES, HYDRAULIC As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	180000 VEHICLE SPEED CONTROL As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-13	110000 ELECTRICAL SYSTEM TSB: REVISION NOTICE July 13, 2017 Rev1: The Repair Procedure, Parts Information and Required Tools & Equipment sections have been updated. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0038-15. The e Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-13	162300 STRUCTURE:BODY:DOOR TSB: REVISION NOTICE July 13, 2017 Rev1: The Repair Procedure, Parts Information and Required Tools & Equipment sections have been updated. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0038-15. The e Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-13	162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS TSB: REVISION NOTICE July 13, 2017 Rev1: The Repair Procedure, Parts Information and Required Tools & Equipment sections have been updated. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0038-15. The e Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-10-30	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-10-27	162300 STRUCTURE:BODY:DOOR TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-23	353000 EQUIPMENT:ELECTRICAL TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	060000 ENGINE (PWS) TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. THIS BUL Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	110000 ELECTRICAL SYSTEM TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-06-13	181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-05-08	117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL TOYOTA: MULTIPLE WARNING LIGHTS ILLUMINATED, VEHICLE NOT SHIFTING FROM PARK TO DRIVE, AND OTHER ACCESSORIES BECOMING INOPERATIVE AFTER VEHICLE HAS COLD SOAKED IN SUBFREEZING AMBIENT AIR TEMPERATURES. *PE UPDAT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-07	060000 ENGINE (PWS) TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN VEHICLES THE RUBBER OIL SUPPLY HOSE, FOR VVT-I ACTUATOR, IS DEGRADING OVER TIME AND CAUSING A LEAKAGE OF OIL, FROM OIL HOSE, PRODUCING AN ILLUMINATION OF OIL PRESSURE LIGHT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353000 EQUIPMENT:ELECTRICAL TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-10	162000 STRUCTURE:BODY TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353000 EQUIPMENT:ELECTRICAL TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-13	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-13	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-13	118000 ELECTRICAL SYSTEM:SOFTWARE Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	110000 ELECTRICAL SYSTEM TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	353000 EQUIPMENT:ELECTRICAL TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-10	162000 STRUCTURE:BODY TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	100000 POWER TRAIN TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353000 EQUIPMENT:ELECTRICAL TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	118000 ELECTRICAL SYSTEM:SOFTWARE TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353000 EQUIPMENT:ELECTRICAL TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	118000 ELECTRICAL SYSTEM:SOFTWARE TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-07	060000 ENGINE AND ENGINE COOLING Dealer Letter: On certain vehicles equipped with a 2GR-FE (V6) engine, the rubber portion of the oil supply hose for the VVT-i actuator may degrade over time. This condition may cause oil to leak from the VVT-i oil hose producing abnormal e Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-07	060000 ENGINE AND ENGINE COOLING Region Letter: On certain vehicles equipped with a 2GR-FE (V6) engine, the rubber portion of the oil supply hose for the VVT-i actuator may degrade over time. This condition may cause oil to leak from the VVT-i oil hose producing abnormal e Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-31	150000 SEAT BELTS Dealer Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-31	350000 EQUIPMENT Dealer Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-31	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Dealer Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-31	152400 SEAT BELTS:REAR/OTHER:BUCKLE ASSEMBLY Dealer Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-31	150000 SEAT BELTS Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-31	350000 EQUIPMENT Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-31	353000 EQUIPMENT:ELECTRICAL Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-31	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	162300 STRUCTURE:BODY:DOOR TSB: OBSOLETE NOTICE-June 12, 2015: This bulletin is now obsolete. Please see T-SB-0038-15. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS TSB: OBSOLETE NOTICE-June 12, 2015: This bulletin is now obsolete. Please see T-SB-0038-15. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	353000 EQUIPMENT:ELECTRICAL TSB: OBSOLETE NOTICE-June 12, 2015: This bulletin is now obsolete. Please see T-SB-0038-15. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	162300 STRUCTURE:BODY:DOOR TSB: Some 2008 – 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does NOT close properly. The back door may get to the fully closed position and then reverse to the open position. In c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS TSB: Some 2008 – 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does NOT close properly. The back door may get to the fully closed position and then reverse to the open position. In c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	353000 EQUIPMENT:ELECTRICAL TSB: Some 2008 – 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does NOT close properly. The back door may get to the fully closed position and then reverse to the open position. In c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	162300 STRUCTURE:BODY:DOOR TSB: OBSOLETE NOTICE-June 12, 2015: This bulletin is now obsolete. Please see T-SB-0038-15. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS TSB: OBSOLETE NOTICE-June 12, 2015: This bulletin is now obsolete. Please see T-SB-0038-15. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	353000 EQUIPMENT:ELECTRICAL TSB: OBSOLETE NOTICE-June 12, 2015: This bulletin is now obsolete. Please see T-SB-0038-15. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	162300 STRUCTURE:BODY:DOOR TSB: Some 2008 – 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does NOT close properly. The back door may get to the fully closed position and then reverse to the open position. In c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS TSB: Some 2008 – 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does NOT close properly. The back door may get to the fully closed position and then reverse to the open position. In c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-12	353000 EQUIPMENT:ELECTRICAL TSB: Some 2008 – 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does NOT close properly. The back door may get to the fully closed position and then reverse to the open position. In c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-08	060000 ENGINE (PWS) TOYOTA: UPDATED INFORMATION REGARDING THE RESPONSE OF THE AIR FUEL RATIO SENSOR, THAT IS INCORRECT AND ALSO, AN INCORRECT OXYGEN SENSOR OPERATION MAY BE PRESENT, DUE TO ECM/PCM PROCESSOR P0606 DTC. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-09	013000 STEERING:GEAR BOX (OTHER THAN RACK AND PINION) TOYOTA: THERE IS A WHINING NOISE WHEN VEHICLE IS DRIVEN ABOVE 35 MPH, FROM FINAL DRIVE GEAR ASSEMBLY AND A REPAIR PROCEDURE HAS AVAILABLE TO ADDRESS THIS ISSUE. MODEL 2008-2013 HIGHLANDER. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-09	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TOYOTA: THERE IS A WHINING NOISE WHEN VEHICLE IS DRIVEN ABOVE 35 MPH, FROM FINAL DRIVE GEAR ASSEMBLY AND A REPAIR PROCEDURE HAS AVAILABLE TO ADDRESS THIS ISSUE. MODEL 2008-2013 HIGHLANDER. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	110000 ELECTRICAL SYSTEM TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	060000 ENGINE (PWS) TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-21	060000 ENGINE AND ENGINE COOLING TSB: Some vehicles equipped with 2GR-FE/FXE engines and a towing package may exhibit a leak or oil seep from the engine’s oil cooler pipes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-23	353000 EQUIPMENT:ELECTRICAL TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 – 2014 model year automatic transmissions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	100000 POWER TRAIN TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-02-10	133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS TOYOTA: WHEN OPERATING THE FRONT SIDE WINDOW GLASS THERE MAY BE A RATTLE OR POPPING NOISE. THE WINDOW MAY ALSO BE INOPERATIVE DUE TO DAMAGED WINDOW MOUNTING TABS. 2008-2010 HIGHLANDER. RM UPDATED 8/10/12. PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2007-05-02	199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS TIRE PRESSURE WARNING VALVE/SENSOR ACTIVATION. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	350000 EQUIPMENT TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-25	010000 STEERING SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-09-06	140000 AIR BAGS TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-09-06	220000 SEATS TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-10-14	162300 STRUCTURE:BODY:DOOR SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	050000 PARKING BRAKE SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2007-09-21	980000 UNKNOWN OR OTHER FLOOR MAT INSTALLATION DURING (PDS) PRE-DELIVERY SERVICE. *NJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-12-21	060000 ENGINE AND ENGINE COOLING TOYOTA: ON SOME VEHICLES, THE ENGINE OIL COOLER PIPES MAY EXHIBIT AN OIL SEEPAGE. INFORMATION HAS BEEN PROVIDED REGARDING THIS ISSUE. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-12-21	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: ON SOME VEHICLES, THE ENGINE OIL COOLER PIPES MAY EXHIBIT AN OIL SEEPAGE. INFORMATION HAS BEEN PROVIDED REGARDING THIS ISSUE. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-18	350000 EQUIPMENT TOYOTA: ON SOME VEHICLES, INFORMATION BEING SENT OUT REGARDING INSTALLATION OF SMART STOP TECHNOLOGY. MODEL YEARS 2003-2010 COROLLA, COROLLA MATRIX, LAND CRUISER, HIGHLANDER RAV4, 4RUNNER, TUNDRA. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-31	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN ENHANCEMENT WARRANTY PROGRAM, ON CERTAIN VEHICLES, HAS BEEN ANNOUNCED TO PROVIDE WARRANTY COVERAGE FOR REPAIRS RELATING TO LEAKAGE OR SEEPAGE ENGINE OIL COOLER PIPE. MODEL 2007-11 S Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-04-16	062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. LIMITED SERVICE CAMPAIGN (LSC) 90K-PHASE 4. REPLACE THE VVT-I OIL HOSE IN CERTAIN 2008 MODEL HIGHLANDER VEHICLES EQUIPPED WITH A 2GR-FE (V6) ENGINE. THE RUBBER PORTION Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-03-19	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: SOME VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A TICKING/CLICKING TYPE NOISE FROM THE CYLINDER HEAD COVER AREA WHICH MAY BE ACCOMPANIED BY A MIL ON AND ONE OR MORE VVT-I RELATED DIAGNOSTIC TROUBLE CODES (DTCS). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-06-24	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-06-24	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) TOYOTA: VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-01	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-06-21	162300 STRUCTURE:BODY:DOOR SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2008-04-15	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY THE HV BATTERY COVER FOR THE 2008 MODEL YEAR HIGHLANDER HV HAS BEEN DESIGNED TO INCLUDE A CONNECTOR COVER. *NJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-22	190000 TIRES SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2007-08-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SPECIAL SERVICE CAMPAIGN – SSC 70E OWNER’S WARRANTY INFORMATION LETTER. *NJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2007-08-25	061000 ENGINE AND ENGINE COOLING:ENGINE ISC LEARNING PROCEDURE. WHEN THE BATTERY IS DISCONNECTED OR LOWER THAN 7 VOLTS, IT IS NECESSARY TO PERFORM THE ISC LEARNING PROCEDURE TO GET IT BACK TO IDLE SPEED CONTROL. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-03-01	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES EQUIPPED WITH A 2GR-FE (V6) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR VVT-I ACTUATOR MAY DEGRADE OVER TIME. THIS CONDITION MAY CAUSE OIL TO LEAK FR Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-03-01	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES EQUIPPED WITH A 2GR-FE (V6) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR VVT-I ACTUATOR MAY DEGRADE OVER TIME. THIS CONDITION MAY CAUSE OIL TO LEAK FR Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2007-04-20	135100 VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR INITIAL CALIBRATION OF COMPASS DURING PDS. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2007-04-20	980000 UNKNOWN OR OTHER SHORT PIN INSTALLATION DURING PDS. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2007-04-17	980000 UNKNOWN OR OTHER FRONT LICENSE PLATE INSTALLATION DURING PD’S. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-03	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PROVIDED REGARDING THE UPDATED OWNER’S MANUAL FOR CERTAIN VEHICLES. MODELS 2008-2012 HIGHLANDER. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2007-04-26	980000 UNKNOWN OR OTHER TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-04	190000 TIRES SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-08-23	162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE TOYOTA: THE REAR LIFT GLASS HATCH EXHIBITS A POSSIBLE CONDITION WHEREBY IT FAILS CLOSE PROPERLY. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-08-23	162610 STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS TOYOTA: THE REAR LIFT GLASS HATCH EXHIBITS A POSSIBLE CONDITION WHEREBY IT FAILS CLOSE PROPERLY. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-08-23	162620 STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE TOYOTA: THE REAR LIFT GLASS HATCH EXHIBITS A POSSIBLE CONDITION WHEREBY IT FAILS CLOSE PROPERLY. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-02-04	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2008 TOYOTA Highlander

13 Recalls for 2008 TOYOTA Highlander

4 Complaints sent to the Center for Auto Safety for 2008 TOYOTA Highlander

355 Complaints submitted to NHTSA for 2008 TOYOTA Highlander

4 Investigations for 2008 TOYOTA Highlander

320 Service Alerts for 2008 TOYOTA Highlander